Industrial air curtain prices in Egypt are not a single fixed number, because every industrial entrance differs in width, height, traffic, wind exposure and temperature difference. An accurate quote starts with reviewing the site details, then choosing a unit whose airstream reaches the full height of the opening and whose width covers the entrance without gaps.
This guide explains what affects the cost of supply and installation, the difference between industrial curtains and small commercial units, and the information that helps you get a suitable technical offer for a factory, warehouse or loading area.
What is an industrial air curtain?
An industrial air curtain is a unit that pushes a continuous airstream across an open entrance to reduce air exchange between inside and outside. The right choice helps limit dust, insects and outside air, and reduces the loss of conditioned or chilled air, while people, equipment and forklifts keep moving through the opening.
An air curtain is not a physical door and does not provide full insulation. Results depend on outside wind speed, pressure and temperature differences, mounting height, air discharge direction and how long the door stays open. See the industrial air curtains details before requesting a site survey.
What determines industrial air curtain prices?
1. Opening width and mounting height
The wider the opening, the longer the unit, or the more units, needed to cover it. Mounting height determines the air throw and the velocity required at floor level, so measuring the width alone is not enough.
2. Air throw and airflow rate
Factory and warehouse entrances need different performance from shop and restaurant doors. Fan and motor capacity, discharge velocity and air throw all affect the unit configuration and its price.
3. Site and wind conditions
An entrance facing direct wind, or located between two zones with a pressure difference, needs a closer review. The mounting position, air direction or number of units may change according to actual site conditions.
4. Operating hours and traffic
Frequent or continuous operation in loading and production areas requires a choice that suits the duty cycle. Daily operating hours, how long the door stays open, and truck or forklift traffic are important factors when comparing offers.
5. Controls and door interlock
Manual or automatic operation, linking the curtain to door movement, and controllers and sensors can be discussed if the unit and system allow it. Every addition should be stated clearly in the technical offer.
6. Casing, finish and working environment
Food, storage, humid or dusty environments may need suitable materials, finishes and maintenance methods. No unit should be assumed suitable for a hygienic or harsh environment before its specifications are reviewed.
7. Mounting, electrical work and access
The assessment covers fixing points, the supporting structure, the power supply, the available working height and the equipment needed for installation. Installation cost can differ between a ready opening and one that needs extra preparation.
Industrial vs. commercial air curtains
Commercial units are usually used for lower entrances with lighter air conditions. Industrial curtains are chosen for large or high-traffic entrances such as factories, warehouses and shipping areas. The real difference is not just the name, but the air throw and the unit's ability to handle the opening height and operating conditions.
Buying a small unit because it is cheaper can result in an airstream that does not reach the bottom of the entrance, so the unit runs without doing its job. The right comparison is between documented performance, site requirements, the scope of supply and installation, and after-sales service.
What information is needed for an accurate quote?
- Entrance width and height, and the unit mounting height.
- Clear photos of the opening from inside and outside, and of the area above the door.
- Type of activity: factory, warehouse, cold storage, food production or loading area.
- How long the entrance stays open and the daily operating hours.
- Wind direction and any noticeable temperature or pressure difference.
- The available power supply and the required operating mode.
- Project location and the expected installation date.
Sending these details through the site survey and quote request reduces assumptions and helps the team review the solution before visiting the site.
Does an air curtain reduce energy consumption?
A correctly selected and installed curtain can reduce air exchange while the entrance is open, but there is no single savings percentage that applies to every site. The result depends on the building, the door, opening time, wind, and the air conditioning or cooling system. Any savings figure should be treated as a result that needs real measurement, not a general promise.
When does an air curtain need maintenance?
A weaker airstream, more noise and vibration, irregular operation, or dust building up on the air intakes are signs that need inspection. Regular cleaning and checking the mounting and connections help keep performance steady. For existing systems you can submit an air curtain maintenance request and attach photos of the problem.
EGY Trading industrial air curtain projects
EGY Trading's track record includes industrial air curtain solutions for PepsiCo, Friday and Snack Land (Twist). These records show the type of solution delivered, while the specifications of every new project are set after reviewing the opening and operating conditions.
FAQ: industrial air curtain prices
Can the price be known from the door width alone?
No. We need the entrance width, mounting height, air conditions, operating hours, control method and mounting work to reach a realistic offer.
Are industrial air curtains suitable for cold stores?
Their use can be studied, but temperature, humidity and pressure differences and door opening time are key factors. The unit must be chosen as part of a site solution, and the opening may need other measures alongside the curtain.
Can more than one unit be installed on one entrance?
Yes, when needed to cover a large width, provided the units are arranged so they leave no gaps in the airstream and the mounting and power supply are reviewed.
Can the curtain work with an automatic door?
Operation can be linked to door movement if the controllers are compatible. This is defined in the technical offer after reviewing the door and the existing system.
What is the next step to get a quote?
Read the industrial air curtain selection guide, then send the measurements, photos and type of use through the contact page. The team will identify any missing information and schedule a site survey if needed. We offer a free site survey and a price quote in under 24 hours.